Nevada Backroaders

Nevada 4-Wheel Drive Club
It is currently Thu Mar 28, 2024 7:33 am

All times are UTC - 8 hours [ DST ]




Post new topic Reply to topic  [ 16 posts ]  Go to page 1, 2  Next
Author Message
 Post subject: FJ Cruiser Frame Failure
PostPosted: Thu Dec 04, 2008 9:44 am 
Offline
User avatar

Joined: Wed May 30, 2007 6:56 pm
Posts: 178
Location: Steamboat Springs, CO.
Hey D-Rail remember the cracking we saw of the frames coating on mine when it was just a month old - looks like some major stress's on front frame section.

Not my FJ one of the guys from AZFJ - http://www.fjcruiserforums.com/forums/m ... frame.html

Image

Image

I broke my frame!
I know fender rips and tears are all the fad, but how about this... I tore my frame!

Passenger side right next to where the motor mount ties into the frame... hard to see from the pics, but the frame is sheared through such that the motor mount arm thingy is no longer attached to anything...

Toyota refuses to warranty it, but the R&D people want the frame so the entire frame is being replaced at no cost to me.

I'm hoping to get a lot of REALLY cool pics as they perform the labor of replacing the frame... since they'll be ripping the body and drivetrain out. Should be interesting. I'll take requests if anybody wants a picture of anything specific that might be better seen with the body off, etc.

EDIT: There wasn't any one incident that caused this... it happened slowly over the course of about a month and several different trail runs. The symptoms were consistent with a broken motor mount (excessive engine movement). I assumed it was a broken motor mount and took it to the dealership... they called me back with something like 'uhhh, I think you better come take a look at this.

_________________
Access Army - Joint Chiefs of Staff
Blue Ribbon Coalition - Life Member
BRC Kickin’ Access Technology (KAT) Team - Charter Member
Graduate of Del Albright's RLTC course
Just Good Trails - Trail Boss
Tread Lightly - Tread Trainer


Top
 Profile  
 
PostPosted: Thu Dec 04, 2008 10:06 am 
Offline

Joined: Thu Jun 09, 2005 10:08 pm
Posts: 840
Location: Caliente, NV
Niiiiiice.

_________________
All Jeep trails had to first be Scouted.

1978 IH Scout II Lifted, locked, blah,blah,blah.
2008 Jeep Grand Cherokee, Her car.
1992 Ford F350 XLT 4x4


Top
 Profile  
 
PostPosted: Thu Dec 04, 2008 1:41 pm 
Offline
User avatar

Joined: Fri Sep 02, 2005 9:05 pm
Posts: 1054
Location: McDonald, Ohio
Wow!! I've ripped brackets off both the front and rear axles on my Jeep, but nothing with the frame. It is still intact.

I'm really surprised they weren't going to fix or replace the frame to begin with. Its like they were saying FJ's shouldn't be wheeled or something. Way to stand behind your products guys!!


Glad to hear that guy is getting it taken care of though. That's really fortunate for his sake!!

_________________
2002 Jeep Wrangler X, ARB's, 4.5" RE lift, 35" KM2's, built to crawl on rocks


Top
 Profile  
 
PostPosted: Thu Dec 04, 2008 4:01 pm 
Offline
User avatar

Joined: Wed May 30, 2007 6:56 pm
Posts: 178
Location: Steamboat Springs, CO.
The FJ Cruisers problems with failing frames, inner fenders, R&Ps ect. Is bad enough but only made worse by Toyota Corp actions or non-action delay tactics. Been waiting since Oct 15th 2007 on mine.

_________________
Access Army - Joint Chiefs of Staff
Blue Ribbon Coalition - Life Member
BRC Kickin’ Access Technology (KAT) Team - Charter Member
Graduate of Del Albright's RLTC course
Just Good Trails - Trail Boss
Tread Lightly - Tread Trainer


Top
 Profile  
 
PostPosted: Thu Dec 04, 2008 11:55 pm 
Offline
User avatar

Joined: Sun Nov 06, 2005 11:12 pm
Posts: 38
SinCityFJC wrote:
The FJ Cruisers problems with failing frames, inner fenders, R&Ps ect. Is bad enough but only made worse by Toyota Corp actions or non-action delay tactics. Been waiting since Oct 15th 2007 on mine.


Think: Ford Pinto. Cheaper to ignore the problem. Bonus advice from the lawyers probably suggests that since few if any people are getting killed because of the defect, why bother to fix it unless Big Brother orders you?

_________________
Andy
"Purple is the new chrome"


Top
 Profile  
 
PostPosted: Fri Dec 05, 2008 4:24 pm 
Offline
User avatar

Joined: Wed May 30, 2007 6:56 pm
Posts: 178
Location: Steamboat Springs, CO.
Well Toyota Corporate is Not going to back their product or honor the warranty on my FJ Cruiser - excuse is that it's lifted & it's a user issue not a product/design problem. Hell will freeze over before I buy another Toyota product.

My web page dedicated to the FJ Cruiser that I'm just starting. http://rides.webshots.com/album/569086712jgHQHb

Plus YouTube Video from yesterday. http://www.youtube.com/watch?v=QIHk8zrjiNo

_________________
Access Army - Joint Chiefs of Staff
Blue Ribbon Coalition - Life Member
BRC Kickin’ Access Technology (KAT) Team - Charter Member
Graduate of Del Albright's RLTC course
Just Good Trails - Trail Boss
Tread Lightly - Tread Trainer


Top
 Profile  
 
PostPosted: Fri Dec 05, 2008 5:01 pm 
Offline
User avatar

Joined: Thu Dec 08, 2005 12:45 pm
Posts: 747
Location: Las Vegas
show them all the commercials with the FJs tearing through the outdoors.

and then serve them papers.


I think if you spend $25,000+ on a vehicle they oughtta kiss your bleep.

especially if the frame fails.


do they seriously have to wait until someone dies from a frame failure?

_________________
Image


ɹǝʌo ǝɯ ןןoɹ sıɥʇ pɐǝɹ uɐɔ noʎ ɟı


Top
 Profile  
 
PostPosted: Fri Dec 05, 2008 6:43 pm 
Offline
User avatar

Joined: Wed May 30, 2007 6:56 pm
Posts: 178
Location: Steamboat Springs, CO.
JJ wrote:
show them all the commercials with the FJs tearing through the outdoors.

and then serve them papers.


I think if you spend $25,000+ on a vehicle they oughtta kiss your bleep.

especially if the frame fails.


do they seriously have to wait until someone dies from a frame failure?


It looks like its going to take someone getting mauled or killed for these issues to get the press they deserve.

_________________
Access Army - Joint Chiefs of Staff
Blue Ribbon Coalition - Life Member
BRC Kickin’ Access Technology (KAT) Team - Charter Member
Graduate of Del Albright's RLTC course
Just Good Trails - Trail Boss
Tread Lightly - Tread Trainer


Top
 Profile  
 
PostPosted: Fri Dec 05, 2008 8:41 pm 
Offline
Site Admin
User avatar

Joined: Thu Oct 02, 2003 8:05 pm
Posts: 1138
Location: Ruth, NV
It is a shame that Toyota won't do right. Would anything like the Lemon Law be of any help???

_________________
"I'm not sure where the trail went, but I've got a Jeep and gas so who cares"

Rubicon Bob
Club President
Rescue Ranger
NBMC / NBCC
03 Rubi/2017 Grand Cherokee
2020 Gladiator Launch Edition


Top
 Profile  
 
PostPosted: Fri Dec 05, 2008 9:41 pm 
Offline
User avatar

Joined: Wed May 30, 2007 6:56 pm
Posts: 178
Location: Steamboat Springs, CO.
Rubicon Bob wrote:
It is a shame that Toyota won't do right. Would anything like the Lemon Law be of any help???


I & many others have filed complaints with various agencies with no luck, guess a appeal to Ralf Nader wouldn't hurt

_________________
Access Army - Joint Chiefs of Staff
Blue Ribbon Coalition - Life Member
BRC Kickin’ Access Technology (KAT) Team - Charter Member
Graduate of Del Albright's RLTC course
Just Good Trails - Trail Boss
Tread Lightly - Tread Trainer


Top
 Profile  
 
PostPosted: Sat Dec 06, 2008 1:48 am 
Offline
User avatar

Joined: Thu Dec 08, 2005 12:45 pm
Posts: 747
Location: Las Vegas
Call John Ensign's office. At the very least they can do some research on the issue for you and get back to you on IF and how you can potentially proceed.

I saw cal lhim because this could be a federal issue, especially if all FJs have the same problem.

_________________
Image


ɹǝʌo ǝɯ ןןoɹ sıɥʇ pɐǝɹ uɐɔ noʎ ɟı


Top
 Profile  
 
PostPosted: Sat Dec 06, 2008 3:35 pm 
Offline
User avatar

Joined: Wed May 30, 2007 6:56 pm
Posts: 178
Location: Steamboat Springs, CO.
JJ wrote:
Call John Ensign's office. At the very least they can do some research on the issue for you and get back to you on IF and how you can potentially proceed.

I saw cal lhim because this could be a federal issue, especially if all FJs have the same problem.


Thanks - another suggestion I was pm'd on a FJ board was this :mrgreen: http://www-odi.nhtsa.dot.gov/complaints/

Turns out I did this ages ago, hasn't injured or killed people yet.

_________________
Access Army - Joint Chiefs of Staff
Blue Ribbon Coalition - Life Member
BRC Kickin’ Access Technology (KAT) Team - Charter Member
Graduate of Del Albright's RLTC course
Just Good Trails - Trail Boss
Tread Lightly - Tread Trainer


Top
 Profile  
 
PostPosted: Mon Dec 08, 2008 3:03 pm 
Offline

Joined: Thu Jun 09, 2005 10:08 pm
Posts: 840
Location: Caliente, NV
All I can say is that I'm really glad I held out on buying one of these. When they first came out, I really looked into getting one (due to the old FJ's track record) but decided to hold out till I heard some feed back. It wasn't long after they were out I heard of the frame/front support issues from others. Guess I'll be sticking with my 30+ year old hunk of iron.

_________________
All Jeep trails had to first be Scouted.

1978 IH Scout II Lifted, locked, blah,blah,blah.
2008 Jeep Grand Cherokee, Her car.
1992 Ford F350 XLT 4x4


Top
 Profile  
 
PostPosted: Wed Dec 10, 2008 2:46 pm 
Offline
User avatar

Joined: Wed May 30, 2007 6:56 pm
Posts: 178
Location: Steamboat Springs, CO.
Update on mine - total BS on all counts - denied coverage on all issues.

Click on pic will take you to full size version.
Image

ps: Big thanks to Tigger my FJ Cruiser will be wearing some custom decals. :twisted:

_________________
Access Army - Joint Chiefs of Staff
Blue Ribbon Coalition - Life Member
BRC Kickin’ Access Technology (KAT) Team - Charter Member
Graduate of Del Albright's RLTC course
Just Good Trails - Trail Boss
Tread Lightly - Tread Trainer


Top
 Profile  
 
PostPosted: Sat Dec 13, 2008 4:44 pm 
Offline
User avatar

Joined: Wed May 30, 2007 6:56 pm
Posts: 178
Location: Steamboat Springs, CO.
A big Thanks to Tigger of Design Werks for making me these "Worst 4x4xFar" decals looks good with the JP magazine one

Image

Still need to install the ones for the hood & windshield. :D

_________________
Access Army - Joint Chiefs of Staff
Blue Ribbon Coalition - Life Member
BRC Kickin’ Access Technology (KAT) Team - Charter Member
Graduate of Del Albright's RLTC course
Just Good Trails - Trail Boss
Tread Lightly - Tread Trainer


Top
 Profile  
 
Display posts from previous:  Sort by  
Post new topic Reply to topic  [ 16 posts ]  Go to page 1, 2  Next

All times are UTC - 8 hours [ DST ]


Who is online

Users browsing this forum: No registered users and 5 guests


You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum

Jump to:  
cron
Powered by phpBB® Forum Software © phpBB Group